srlbotanical Posted March 5, 2006 Share Posted March 5, 2006 I am looking for more info on TSB 01-06-03-005 for headlight flicker. Thanks, Steve Link to comment Share on other sites More sharing options...
srlbotanical Posted March 5, 2006 Author Share Posted March 5, 2006 Note the vehicles this applies to. You don't have a bosch generator. <{POST_SNAPBACK}> Thank you! My other vehicle is a 2000 Venture. The light flicker is driving me loony. Steve Link to comment Share on other sites More sharing options...
GM-Tech Posted March 5, 2006 Share Posted March 5, 2006 Note the vehicles this applies to. You don't have a bosch generator. Interior and Exterior Lamps Vary in Brightness (Replace Generator Voltage Regulator Ground Screw) #01-06-03-005 - (Apr 30, 2001) 2000-2001 Chevrolet Impala (With 3800 Engine and Police or Taxi Package) 2000-2001 Chevrolet Venture 2000-2001 Oldsmobile Silhouette 2000-2001 Pontiac Montana Condition Some customers may comment that the interior and/or the exterior lamps vary in intensity (flicker). Correction Replace the voltage regulator attaching screw with the screw and washer from the service kit following the procedure outlined below. Disconnect the battery cable. Remove the wiper module cover (U-Van). Remove the voltage regulator ground screw (1). (This is the recessed screw located 1/3 of the way from the large battery cable attachment to the generator harness.) Use a stubby #2 Phillips screwdriver to break it loose and then loosen the screw with a small pocket screwdriver. The screw may hang up on the plastic cover on the rear of the generator. If this happens, use a pocket screwdriver inserted between the screw and the cover. The screw will pop out when a little sideways pressure is applied. Install the screw and washer from the kit through the voltage regulator and into the generator case. Tighten the screw securely. Replace the wiper module cover. Reconnect the battery cable. Tighten Tighten the cable to 15 N·m (11 lb ft). Parts Information Part Number Description 10316685 Kit, Screw for Bosch Generator Parts are expected to be availalbe from GMSPO, 5/16/01. Warranty Information For vehicles repaired under warranty, use: Labor Operation Description Labor Time J4100 (Impala) Screw, Voltage Regulator Mounting 0.2 hr* J4100 (U-Van) 0.3 hr* *This is a unique labor operation time to be used only with this bulletin. GM bulletins are intended for use by professional technicians, NOT a "do-it-yourselfer". They are written to inform these technicians of conditions that may occur on some vehicles, or to provide information that could assist in the proper service of a vehicle. Properly trained technicians have the equipment, tools, safety instructions, and know-how to do a job properly and safely. If a condition is described, DO NOT assume that the bulletin applies to your vehicle, or that your vehicle will have that condition. See your GM dealer for information on whether your vehicle may benefit from the information. WE SUPPORT VOLUNTARY TECHNICIAN CERTIFICATION © Copyright General Motors Corporation. All Rights Reserved. Link to comment Share on other sites More sharing options...
Question
srlbotanical
I am looking for more info on TSB 01-06-03-005 for headlight flicker.
Thanks,
Steve
Link to comment
Share on other sites
0 answers to this question
Recommended Posts
Archived
This topic is now archived and is closed to further replies.