Jump to content

Chevy Aveo Gas Mileage

whitefish

By whitefish
in The Off-Topic Bar

Recommended Posts

whitefish Enthusiast

whitefish

Posted
Posted

Hi Everyone,

 

I'm getting nowhere on the chevroletforum site with this, so I thought I would ask here.

 

I recently read a post on ways of improving fuel mileage on Chev Aveo's. As per the post, I replaced my air cleaner (which was a fairly new OE GM air cleaner) with a K&N filter and a set of new spark plugs. The old stock air cleaner looked okay, but the spark plugs were BADLY eroded - stock Ac Delco non-platinum/iridium with about 70k on it at the time. Mileage jumped from about 350km per tank (mostly highway miles) to over 500km per tank (sometimes over 550km).

 

My mileage is starting to drop again to around to an horrible 350 to 380km per tank. I cleaned the K&N air cleaner (as per instructions and replaced filter oil) and checked the plugs. Some slight erosion, but still in spec (0.044 inch gap). The spark plugs were pretty black (sooty) and smelled of fuel, so I think the car is running rich. MAF or oxygen sensor?

 

 

My only other thoughts are that mileage would be dropping (now down about 20%) due to the change in temperature or winter grade fuel - I did the tune up in summer when the temp was about 25C and now its about 5C.

 

Any ideas....?

 

Thanks guys.....

desrtrat Senior Enthusiast

desrtrat

Posted
Posted

what year Aveo do you have.. i have a 08 LT sedan w/ 5 sp and i use to get avg. 37-39 mpg with it. now i can sometimes only get 33 mpg with the same driving. i have taken mine to 2 different dealers and no one can give me a answered as to why. the first 10,000 mi i was getting 41-43 mpg. that includes a round trip from Ca. to NY city. i understand lousing mpg when we are forced Fed winter gas at 10% ethanol, but not the rest of the time..i'm at 28,000 now and when i get the chance i'll put pluge in and see what happens....

 

BTW.. no MAF on these motors

 

good luck

whitefish Enthusiast

whitefish

Posted
  • Author
Posted

Its a 2005.

 

For your mileage, is that US gal/mile or imperial? The best I EVER got was about 35 US gal/mile (about 42 IMP MPG). This is when I first got mine at around 10,000 miles, but it went down from there. I was amazed it jumped back up again to 42 MPG after the tune up!

 

I reset the computer by pulling the battery cable and I think mileage may be back up again (I haven't gone through a tank yet). Must have been an error code - all the more reason I need to get a scanner.

Nytemare Senior Enthusiast

Nytemare

Posted
Posted

you may have an O2 sensor starting to go....just not enough out of tolerances to cause a CEL yet. That combined with winter fuel....mileage can drop a lot.

 

Make sure you give it some good Injector cleaner too....like Techron... it could have dirty injectors.

Nytemare Senior Enthusiast

Nytemare

Posted
Posted

GM dealerships also have an intake cleaner that they snake through the entire intake to clean it out. And you could also try some Seafoam to clean the top end. That will help a lot.

desrtrat Senior Enthusiast

desrtrat

Posted
Posted
Its a 2005.

 

For your mileage, is that US gal/mile or imperial? The best I EVER got was about 35 US gal/mile (about 42 IMP MPG). This is when I first got mine at around 10,000 miles, but it went down from there. I was amazed it jumped back up again to 42 MPG after the tune up!

 

I reset the computer by pulling the battery cable and I think mileage may be back up again (I haven't gone through a tank yet). Must have been an error code - all the more reason I need to get a scanner.

 

mine is US gal/MILES

 

 

GM dealerships also have an intake cleaner that they snake through the entire intake to clean it out. And you could also try some Seafoam to clean the top end. That will help a lot.

 

you can also use Deep Creep also from Seafoam and clean your throtle body while your at it..

 

good luck

whitefish Enthusiast

whitefish

Posted
  • Author
Posted
mine is US gal/MILES

 

Thats outstanding. So you are getting 450 to 500 miles per tank? I have a 4sp auto and I drive at about 60mph when commuting.

 

GM dealerships also have an intake cleaner that they snake through the entire intake to clean it out. And you could also try some Seafoam to clean the top end. That will help a lot.

 

When you say top end, do you mean down the cylinders or throttle body?

 

Never heard of Deep Creep, but I've been told to use GM Carb Cleaner on the throttle body of my 05 Silverado by a GM shop forman. Same idea?

 

Well, pulling the battery cable cleared something. Last tank was 500+ km.

 

Thanks guys. This site bets the crap out of chevroletforum. STILL no responses there.

Nytemare Senior Enthusiast

Nytemare

Posted
Posted

By top end I mean the Throttle body, intake, valves, piston tops, and the top compression ring.

You pour the Seafoam/deep creep down the T-body modulating the throttle to keep the car going until it finally stalls out. You let the product sit for 10-15 min than start the car up and watch the smoke show. When all the smoke clears up your top end is clean as a whistle.

 

I know the Seafoam can be used in the tank to do a similar job and clean the entire fuel system, and it can also be used in the oil to clean out deposits right before you change your oil. Not sure if deep creep can be used the same way.

 

Just follow the instructions on the bottle for best results.

 

The fact that you got better economy after disconnecting the battery tells me that you may have a sensor going bad.

 

Unless you have an adaptive ECM that changes shift points etc with the way you drive...Do you have kids that drive your car??

whitefish Enthusiast

whitefish

Posted
  • Author
Posted
By top end I mean the Throttle body, intake, valves, piston tops, and the top compression ring.

 

Thats what I thought.

 

Unless you have an adaptive ECM that changes shift points etc with the way you drive...Do you have kids that drive your car??

 

Nope, kids aren't old enough to drive. Just the wife and I. I think its a sensor too. Losing almost 40% of my gas mileage in one tank can't be ECM related, can it?

 

Awesome, thanks alot. I'll give the Sea Foam a try.

Nytemare Senior Enthusiast

Nytemare

Posted
Posted

It could be if you were flogging it...but not in one tank.

I don't know if these cars have the adaptive program at all...but having kids that flog your your car would explain some of your mileage decrease. But since that's not the case I would go with sensor...you just have to wait till it goes and throws a light.

 

The Seafoam or deep creep will clean the O2 Sensor also if its just dirty. Also, have a sniff of your exhaust to see if there is a "rotten egg" smell, this will indicate that you could have a catalytic converter going bad.

desrtrat Senior Enthusiast

desrtrat

Posted
Posted

here is a link for Sea foam. just click on the product, and will explain all

 

http://www.seafoamsales.com/

 

the vid shows them :thumbs: poring the Sea foam WAY to fast :D with the motor running. i can't say why they did it that fast, but YOU CAN hammer lock a motor that way..i just let it suck out of the can slowly..

 

good luck

90454SS Enthusiast

90454SS

Posted
Posted

If you know someone with an obd2 scanner you can watch the O2 sensor(s) activity. There is a range that the reading fluctuates and it can stay in the low or high range or proceed through that range slowly if there are issues. Then a good mechanic can trace where\what the problem is. Good luck!

whitefish Enthusiast

whitefish

Posted
  • Author
Posted

I do know a "retired" GM Tech (affected by GM's decision to close small delearships) - I'll have to see if he has a obd2 scanner. I'm thinking of getting a obd2 handheld or pc software anyways.

 

I would go with sensor...you just have to wait till it goes and throws a light.

 

Is it possible that an error code will be registered without the "Check Engine Light" going on?

 

 

Also, have a sniff of your exhaust to see if there is a "rotten egg" smell, this will indicate that you could have a catalytic converter going bad.

 

No rotten egg smell.

Nytemare Senior Enthusiast

Nytemare

Posted
Posted
I would go with sensor...you just have to wait till it goes and throws a light.

 

Is it possible that an error code will be registered without the "Check Engine Light" going on?

 

 

It is possible, get it read...its fairly cheep. The Tech2 scan tool is probably your best bet though, like was said...it will check the O2 sensors activity and operating range.

 

Oh by the way, another sensor to check is the Air intake Temp sensor. Just plug a multi-meter into both connection points and read resistance. If its out of whack it will dump fuel into the engine as it thinks its colder outside and the engine requires more fuel. This sensor will not throw a code, as long as the resistance values are present...it will only code when the circuit is an open.

Archived

This topic is now archived and is closed to further replies.

Go to topic listing

  • Recently Browsing   0 members

    • No registered users viewing this page.

  • Forum Statistics

    250.4k
    Total Topics
    2.7m
    Total Posts

  • Member Statistics

    342,760
    Total Members
    8,960
    Most Online
    MASONV88888888
    Newest Member
    MASONV88888888
    Joined

  • Who's Online   0 Members, 0 Anonymous, 1,552 Guests (See full list)

    • There are no registered users currently online

  • Latest Articles

  • Posts

    • Coastie05
      Replacing 2.7L on 2021 Silverado with 2023 2.7L

      By Coastie05 · Posted

      I’m definitely interested to hear the end result here. 
    • MASONV88888888
      Another 6.2L engine failure!

      By MASONV88888888 · Posted

      My 2025 Silverado 1500 had to receive a brand-new engine (long block) under warranty last month at only around 16,500 miles. Before the replacement, the truck repeatedly displayed "Engine Oil Level Low" warnings, even though the Oil Life Monitor still showed around 50% remaining after about 6,000 miles since my last oil change. After seeing the warning several times, I checked the dipstick with the engine cold, and the oil level was completely normal. The next day, the message escalated to "Add Engine Oil." At first, I assumed it was just a faulty oil level sensor, so I brought the truck to the dealership. After inspecting the engine, they found internal cylinder wall scoring and ultimately replaced the entire long block under warranty. Before this happened, I was planning to install a 4-inch lift and suspension upgrade on my truck. After needing a new engine at just 16,500 miles, I honestly don't see the point anymore. I also contacted GM to ask whether my vehicle qualified for a buyback, but I was informed that it does not at this time. Anyway, this experience has left me with serious concerns about the long-term reliability of this engine. I sincerely hope NHTSA expands the current investigation or recall to include 2025 model and performs a thorough inspection of affected vehicles. My biggest concern is that these engines may fail shortly after the powertrain warranty expires. If GM truly stands behind this engine, then at the very least, please consider extending the powertrain warranty to 10 years for affected owners. That would go a long way toward restoring customer confidence.
    • Grumpy Bear
      OCI, not when but why?

      By Grumpy Bear · Posted

      Without exception but then I'm the odd duck, right? I know what goes into that test, how it is calculated and thus how to beat it. But EPA values are often not beaten by the general public and the government has in past years adjusted the means and methods to come to those values to more closely approximate "Joe Average".    The only real trick to beating that EPA average is don't drive like "Joe Average".    It's the same method you used to profit from "Economic Migration" and in doing so beat the 'stats'. But you, like me, are not "Joe Average".     The thing you don't seem to grasp is this "Purchasing Power Index" isn't forward looking. It doesn't predict what it going to be but looks backward and states what it was. They are not telling us what the THINK, they are telling us what they MEASURED. Example:    Wife says "I'm going to lose 40 pounds by Christmas". May she does, maybe she doesn't but the doctors office who weighed her when she made that statement and again at Christmas only REPORTS what the RESULT was. You and I can banter about what was possible and what aunt Tilly did till the cows come home but the result is the result. Arguing otherwise is.....irrational. That's all I'm saying. This isn't about:      What you are calling a 'Statistic' is a RESULT not a CALCUATION and as a result the RULE. Like gravity as a rule, it can not be broken. 
    • MASONV88888888
      Rattle in the rear!

      By MASONV88888888 · Posted

      Just wanted to say thank you for posting this. Years later, your thread is still helping Silverado owners.   I bought my 2025 Silverado 1500 in January 2025, and I've had what feels like the exact same rattle since day one. After reading your findings, I believe my truck has the same issue with the cable carrier contacting the rear sliding window. To be honest, I had pretty much given up on pursuing the issue. It wasn't until I recently drove another brand's pickup that I realized just how quiet their cabin was—and how noisy mine has been all along. On my truck, the rattle happens on almost any paved road, gets even worse on rougher pavement, and I can even hear it during braking and acceleration.   I actually referenced your thread when submitting my case to GM, hoping they'll recognize this as a recurring issue instead of treating it as an isolated incident. The reason I reached out to GM first is because my dealership told me they would need to keep the truck for at least two days just to diagnose the problem. I was concerned that even after two days, they still might not be able to identify the source of the rattle before giving the truck back to me. I had also asked a few dealerships about this issue during previous service visits, but none of them seemed to know what was causing it or had a solution. That's why I decided to contact GM directly first, hoping they might already have an official repair procedure or guidance for this issue.   I also hope GM eventually comes up with an official fix for this problem. I have a feeling there are many Silverado owners experiencing the same rattle, but most either choose to live with it or simply don't know what the cause is.   Really appreciate you taking the time to document your diagnosis. Your post is still making a difference years later.
    • Buckwild27
      Gas Prices

      By Buckwild27 · Posted

      I have 2 choices. 

  • GM-Trucks.com Clubs

  • Popular Contributors

×
×
  • Create New...