Jump to content

axle shooting grease after level

Licustom
 Share

Recommended Posts

Licustom Enthusiast

Licustom

Posted
  • Author
Posted (edited)
10 hours ago, andrewb24 said:

so you had regular axles like for an LT and swapped to Trail Boss axles??   what all did you have to remove to get axle out other than the wheel and axle nut?  what did you use or how did you get the inner axle pulled out?

I replaced what ever axle comes stock in my custom with trail boss axles. Part number 84554912. Removed axle nut separated bottom ball joint and popped axle out of diff. Wasn’t bad, the dealer showed me why the quote was so high and it was because book says to pretty much disassemble the complete suspension on the given side. 

Edited by Licustom
  • 2 months later...
Hn9ne123 New Member

Hn9ne123

Posted
Posted
On 9/29/2020 at 6:50 PM, Licustom said:

I ended up replacing mine with part number 84554912. The axle itself isn’t longer the inner tulip is and allows more travel of the CV. I haven’t had any issues after installing these axles. 
 

Be careful where you have them installed also, I was quoted labor as 3 hours per side from gm and an Indy shop. Ended up doing it myself 45 minutes per side. 

Any news or updates on those trial boss axles? I’m having the same issue the reason I have was like three torn boot on both sides on my head I’m trying to decide if I should go run trail boss and axles soon as It seems more built for it since the trail boss it comes with a already factory 2” level lift up front? 

  • 6 months later...
Licustom Enthusiast

Licustom

Posted
  • Author
Posted
On 2/2/2021 at 2:32 PM, Hn9ne123 said:

Any news or updates on those trial boss axles? I’m having the same issue the reason I have was like three torn boot on both sides on my head I’m trying to decide if I should go run trail boss and axles soon as It seems more built for it since the trail boss it comes with a already factory 2” level lift up front? 

I have since sold the truck…. I put about 25K on the trail boss axles and had 0 problems. What size level kit did you use? Is it too spacer or bottom?

11bravoZ71 Enthusiast

11bravoZ71

Posted
Posted

Hey licustom. I’m planning on swapping out my LT axles To trailboss axles like you did.. You mentioned that the length was the same on them… but I wanted to ask though did the cv angles actually get better visibly vs those LT ones?  
 

Here are my angles with a 2 inch trailboss suspension plus 1.5 level from rough country on my LT 4x4.  total of 3.5 inch lift… wanting to see if getting the trail boss axles are worth it for the long term.  Or if my angles look fine. I do off road pretty often  for what it’s worth and use 4x4 often. 

3EF09287-B6B1-4185-96E1-3475455A2546.jpeg

  • 1 year later...
Josecp28 New Member

Josecp28

Posted
Posted
On 11/20/2020 at 9:19 AM, andrewb24 said:

so you had regular axles like for an LT and swapped to Trail Boss axles??   what all did you have to remove to get axle out other than the wheel and axle nut?  what did you use or how did you get the inner axle pulled out?

Did you ever find out? I also would like to know if i can use trail-boss axles on my LT, just busted my cv axles cause of my lift and im hoping the TB axles work better 

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now
 Share
Go to topic listing

  • Recently Browsing   0 members

    • No registered users viewing this page.

  • Forum Statistics

    250.4k
    Total Topics
    2.7m
    Total Posts

  • Member Statistics

    342,760
    Total Members
    8,960
    Most Online
    MASONV88888888
    Newest Member
    MASONV88888888
    Joined

  • Who's Online   1 Member, 0 Anonymous, 1,647 Guests (See full list)

  • Latest Articles

  • Posts

    • Coastie05
      Replacing 2.7L on 2021 Silverado with 2023 2.7L

      By Coastie05 · Posted

      I’m definitely interested to hear the end result here. 
    • MASONV88888888
      Another 6.2L engine failure!

      By MASONV88888888 · Posted

      My 2025 Silverado 1500 had to receive a brand-new engine (long block) under warranty last month at only around 16,500 miles. Before the replacement, the truck repeatedly displayed "Engine Oil Level Low" warnings, even though the Oil Life Monitor still showed around 50% remaining after about 6,000 miles since my last oil change. After seeing the warning several times, I checked the dipstick with the engine cold, and the oil level was completely normal. The next day, the message escalated to "Add Engine Oil." At first, I assumed it was just a faulty oil level sensor, so I brought the truck to the dealership. After inspecting the engine, they found internal cylinder wall scoring and ultimately replaced the entire long block under warranty. Before this happened, I was planning to install a 4-inch lift and suspension upgrade on my truck. After needing a new engine at just 16,500 miles, I honestly don't see the point anymore. I also contacted GM to ask whether my vehicle qualified for a buyback, but I was informed that it does not at this time. Anyway, this experience has left me with serious concerns about the long-term reliability of this engine. I sincerely hope NHTSA expands the current investigation or recall to include 2025 model and performs a thorough inspection of affected vehicles. My biggest concern is that these engines may fail shortly after the powertrain warranty expires. If GM truly stands behind this engine, then at the very least, please consider extending the powertrain warranty to 10 years for affected owners. That would go a long way toward restoring customer confidence.
    • Grumpy Bear
      OCI, not when but why?

      By Grumpy Bear · Posted

      Without exception but then I'm the odd duck, right? I know what goes into that test, how it is calculated and thus how to beat it. But EPA values are often not beaten by the general public and the government has in past years adjusted the means and methods to come to those values to more closely approximate "Joe Average".    The only real trick to beating that EPA average is don't drive like "Joe Average".    It's the same method you used to profit from "Economic Migration" and in doing so beat the 'stats'. But you, like me, are not "Joe Average".     The thing you don't seem to grasp is this "Purchasing Power Index" isn't forward looking. It doesn't predict what it going to be but looks backward and states what it was. They are not telling us what the THINK, they are telling us what they MEASURED. Example:    Wife says "I'm going to lose 40 pounds by Christmas". May she does, maybe she doesn't but the doctors office who weighed her when she made that statement and again at Christmas only REPORTS what the RESULT was. You and I can banter about what was possible and what aunt Tilly did till the cows come home but the result is the result. Arguing otherwise is.....irrational. That's all I'm saying. This isn't about:      What you are calling a 'Statistic' is a RESULT not a CALCUATION and as a result the RULE. Like gravity as a rule, it can not be broken. 
    • MASONV88888888
      Rattle in the rear!

      By MASONV88888888 · Posted

      Just wanted to say thank you for posting this. Years later, your thread is still helping Silverado owners.   I bought my 2025 Silverado 1500 in January 2025, and I've had what feels like the exact same rattle since day one. After reading your findings, I believe my truck has the same issue with the cable carrier contacting the rear sliding window. To be honest, I had pretty much given up on pursuing the issue. It wasn't until I recently drove another brand's pickup that I realized just how quiet their cabin was—and how noisy mine has been all along. On my truck, the rattle happens on almost any paved road, gets even worse on rougher pavement, and I can even hear it during braking and acceleration.   I actually referenced your thread when submitting my case to GM, hoping they'll recognize this as a recurring issue instead of treating it as an isolated incident. The reason I reached out to GM first is because my dealership told me they would need to keep the truck for at least two days just to diagnose the problem. I was concerned that even after two days, they still might not be able to identify the source of the rattle before giving the truck back to me. I had also asked a few dealerships about this issue during previous service visits, but none of them seemed to know what was causing it or had a solution. That's why I decided to contact GM directly first, hoping they might already have an official repair procedure or guidance for this issue.   I also hope GM eventually comes up with an official fix for this problem. I have a feeling there are many Silverado owners experiencing the same rattle, but most either choose to live with it or simply don't know what the cause is.   Really appreciate you taking the time to document your diagnosis. Your post is still making a difference years later.
    • Buckwild27
      Gas Prices

      By Buckwild27 · Posted

      I have 2 choices. 

  • GM-Trucks.com Clubs

  • Popular Contributors

×
×
  • Create New...