Jump to content

Recommended Posts

Posted

Other side taken care of. Now to wait for more parts

17c039dcddd522f4d28a947c25b4f725.jpg

Posted

Grille had to be modified to fit the parking lights

29f30be2956c0afb2a2b6f91f6767002.jpg

Posted

Hey little puppy! :D (I say that to all dogs regardless of age, in as high a pitched voice as I can - makes them all go absolutely bonkers, lol).

 

That's gonna look sweet - I can tell already. :thumbs:

  • Like 1
Posted

Well blower motor number 4 is acting up now. Intermittenly cuts in and out on all speeds. Could it really be another blower motor?

Posted

Somehow USPS damaged my bumper reinforcement in shipping. Confused me since it is a big piece of hard plastic meant to take a hit. But Amazon decided to overnight a replacement since delivery of the "damaged" one wouldn't even be delivered. I'm hoping both bumper braces come tomorrow as well.

  • Like 1
Posted

Well blower motor number 4 is acting up now. Intermittenly cuts in and out on all speeds. Could it really be another blower motor?

Sounds like something is causing them to go bad...

Posted

Somehow USPS damaged my bumper reinforcement in shipping. Confused me since it is a big piece of hard plastic meant to take a hit. But Amazon decided to overnight a replacement since delivery of the "damaged" one wouldn't even be delivered. I'm hoping both bumper braces come tomorrow as well.

I've seen chunks of metal damaged, anything plastic is child's play.
Posted (edited)

Wonder if there's a problem in the electronics that's feeding too much voltage to the motor somehow? Don't see how that could be possible unless it was designed to run on less than normal battery voltage. That's about all that would cause a motor to fail, besides excessive heat (normally not an issue with fans, but a bad connection with high amperage can get REAL hot), or water intrusion.

 

The other variable could be that they're just complete and utter chinese garbage ...

Edited by Jsdirt
  • Like 1
Posted

Are they new or are you just pulling them out of junk yards?

Posted (edited)

They have been all new gm ones. I will check the voltage tomorrow. I am leaning towards just utter crap parts though. It's almost exactly what I went through when I bought the truck.

Edited by NEFisher11
  • Like 1
Posted

Went to open my extend cab door on the drivers side this morning and the damn handle broke. Junk plastic. Ordering a new metal one off of Ebay.

Posted

WTF, unreal! :nonod:

 

 

Yesterday I installed a new master cylinder in my sister-in-law's '04 Olds Alero. Thing only has 63k, so I suspect the seals failed from all the years of sitting.

 

Fairly easy job - took me an hour, mostly thanks to the CRAP lines included for bench bleeding. Friggin things were stiff as concrete! Every time I tried to bend them around to put them into the reservoir, they'd pop off the plastic port fittings. MAN was I getting pissed! :banghead: Totally useless. Part of the problem was it was 15°F out there as I was doing all of this. Ended up giving up on those, and cut 2 lengths of my good Tygon C-210-A clear hose, and ran a zip-tie under the reservoir to hold them in position to bench bleed. What a joke! I had about a half pint of brake fluid all over the vice, floor, and everything close by. :mad:

 

Sent her on her way just as the Autoparts International guy dropped off a fuel pump and strainer (that I didn't need) for that '95 940 wagon I've been working on. Jumped into that and had it running in a couple hours. After finishing that, I attempted to turn the rusty p/s pump belt adjuster, and snapped the 6mm x 100mm bolt in half. Grabbed one off my parts car's A/C compressor, and broke that one too attempting to straighten a bend in it without heat. Then I experienced a 37 MPH (according to my Davis weather station on the roof) wind gust that slammed the hood down on my head. Luckily I was wearing a hat, and the insulation was still intact under the hood. I could've fought Mike Tyson and won after the day I had! :lol:

 

Strange failure of that fuel pump. Took me a bit of time to get there - at first I was convinced it was an electrical problem. Car would fire up, idle, and run perfectly every morning, but, at the first stop sign about a mile out, it would crap out and never start again the rest of the day. Poor guy spent close to $2k throwing parts at this thing trying to fix it. Did all the usual Volvo failure items: radio suppression relay, crank position sensor, fuel pump relay, etc.. - none of it fixed it. So I had it idling on the trailer here for almost 45 minutes - still running fine. So I got in and held the throttle at 3k for a minute or so to simulate driving, then slammed the throttle shut. Immediately I could hear cylinders dropping out one by one. To my surprise, my timing light was still flashing all the way until it stalled. Time to grab the fuel pressure gauge. Yep - 0 psi! BUT .. the pump was clearly running! Could hear it prime, and could hear it the whole time it would stall out. Really strange! Long story short, I yanked the pump and hooked it up to a battery in the driveway, and put the sock into a yogurt container full of acetone. Hooked to battery, the pump ran, but not a single drop came out! After tapping the ground wire to the battery, rapidly turning the pump off and on, it made a POP, then acetone shot 5' in the air. Plugged check valve! That was an odd one!

 

Walbro pump too - those are normally pretty good. Guy said he had just changed this thing recently, which is why he completely avoided fuel system troubleshooting. Goes to show ... !!

 

IMG_6729_zpsiwd5psmo.jpg

 

IMG_6727_zpsh2yjxrsh.jpg

 

IMG_6728_zpsn32fnfxm.jpg

Posted (edited)

The braces came in. Now waiting on the bumper and I can start getting things lined up

c23a70c6a1a944b0ebaf7a126a98ac54.jpg

Edited by Chris
  • Like 2

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now

  • Latest Articles

  • Posts

    • Can it still be Assembled I?    Stribeck says that we need a certain amount of viscosity under conditions of load and velocity to prevent two surfaces of a know roughness from tearing each other asunder. And we have marketing trying to tell the masses that those two surfaced require less of that commodity due to more exact limits being placed on the same old clearances. We also know that there are limits to how hard something can before it becomes to brittle to be viable and to smooth to 'wet' the surface and that both of those conditions have been known and met since about the Second World War.    That viscosity value shook out at 10 centistokes at 212 F just under a hundred years ago.  Give this a look: [Anton Parr]     What is advertised is the Kinematic viscosity (mm2/s) or that which has been density adjusted but the value we are after is the dynamic viscosity (mPa.s) or true viscosity. You can see that this number is dependent on density thus base stock and temperature. You can also see that an SAE 30 doesn't reach that value in this example. However an SAE 30 that is at the upper end of the SAE 30 range; 12.5 cSt (mm2/s), might. 12.5 * .83 = 10.375 (mm2/s). If you could find an SAE 30 at the upper end these days.   Then there is the complication of viscosity modifiers or VII or VM, whatever you wish to call them. Polymers added to very thin base oils, perhaps 3 to 6 cP oils, that will meet the SAE *W30 spec at 'tested' shear rates and 100 C/212F  target temperature. So a polymer fortified base that is a fraction of the 10 cP requirement Stribeck insist upon.   This could be all well and good if those polymers didn't have two very problematic 'features'. They shear or loose viscosity both 1.) permanently and 2.) temporality. And they do both omitted in the advertised data with the distinct  purpose of deceiving the consumer of the actual operating state of the fluid. I've shown the example of Warren Oils COSTCO 10.91 cSt 5W30 formuation several times where the 100 C HTHS value is 6.9 cP!! That's the temporary shear down and with and SSI or shear stability index of 9.4 cSt. Note the intentional deception in using mixed units?    After a short while that 9.4 cSt oil has a viscosity corrected dynamic value of 7.8 cP. But as the SSI is still within the range of an SAE *W30 whose lower value is 9.3 cSt.    This allows them to continue to call this SAE 16 weight oil a 30 weight, the cake, and still meet the API requirements for fuel efficiency IMPROVEMENT mandated by the EPA. The eating of the cake. By the time you've worn out your motor doing the responsible thing by adhering to the warranty requirements, (the stick), you get deprived of the carrot, wear control. So sad, to bad.   So what can be done? Do I need actually say? [Anton Parr]       Even this must be monitored if the oil is on the low side and the VII an organic or you opt for a 0W40 with an even lighter base oil and more / higher MW VII. (Note the lower density of the 40 weight versus the SAE 30 mono-weight?)    There is another workaround. Temperature. An SAE *W30 run at a bulk temperature of between 180 and 195 F.    Being the belt and suspenders sort I am I do both. Run it cook and run it heavy.    In Part II I'll work the AW package. 
    • So, do I go elbow-deep on this thing or list it for sale and play dumb? Seems to "runs good."   I'm about $1200 away from having: -a rebuilt injector ($300) -a new cat ($250) -a new cat back exhaust (OE style) ($300) -a new AC compressor ($200) -AC refrigerant charge ($150)   In theory, this should rectify the obvious detracting issues from its value and operability. Cold AC with a non-squeaking AC pulley both sounds and feels good. An exhaust that isn't cut/hacked in 17 different places and doesn't vibrate on a crossmember would make it sound and feel less janky. A working cat would help the stink, and will save the earth, but *if and only if* the fuel system is working properly, which would also address the intermittent "rich" CEL.   Heard a good one... CEL for "Rich condition" means you haven't spent enough money on the truck lately, and it's letting you know.   Rebuilding the injector would seem to be the most important part. Replacing the cat would be secondary. I don't think mine is plugged or overly restricted, but it might be a little restricted? I have no good way to tell other than seat of the pants feel. I hate the smell.   The current theory is I have a rich idle problem: A bad fuel pressure regulator, or a leaking injector(s) being the highest probabilities. I already replaced the FPR but that doesn't mean its replacement isn't also bad. It was a new part from Dorman, but the packaging looked like it had been sitting on a shelf for 20 years.   This is the (single) upstream O2 sensor shown at idle. I'm getting a lot of "rich" it seems. Sometimes it stays high like that and doesn't drop down. That makes me think it's processing injector leaks or a partially stuck open injector.     Other times it looks like this. Nice oscillations between rich and lean, which is what I think it should be. Under load and at speed, the oscillations are nice and tight and uniform looking, high and low.     Fuel trims suggest the PCM is compensating pretty hard at idle to pull fuel out. But it's not enough to trip a CEL. Something about slowing to a stop: brake vaccum booster, EGR, or the EVAP purge is delayed, or there's pooled fuel in the intake again that's draining into a cylinder is enough to set the CEL. Of course, in two days of driving, it hasn't set. I was hoping to actually look at the freeze-frame data when it sets. IAT is high because it's idling on an 83 degree day here.  
    • Have considered installing a DC to DC charger in your camper to replace your isolator?  
    • Common failure.  You need to replace the fuel door housing.   The painted cover transfers over to the new housing.  To remove the old one there is 4 spots where you poke the plastic to release it.  
    • No such thing as regenerative braking on a pure ICE vehicle.     Regenerative braking is the re-capture of energy from electric motors and stores it in the battery pack.  So hybrids, PHEV and EVs have regenerative braking.     What you are seeing is the charging system changing modes is all.  Its likely entering charge mode for some sort of reason is all.  All of the charging modes will be listed below.   As for L10 vs D.  L10 turns off automatic grade braking.  L10 puts you in control of grade downshifts where in D it will automatically do it based on brake pedal position and other factors.  Otherwise L10 and D drive exactly the same aside from that one aspect.    Battery Sulfation Mode The BCM will enter this mode when the interpreted Generator output voltage is less than 13.2 V for 45 minutes. When this condition exists the BCM will enter Charge Mode for 2–3 minutes. The BCM will then determine which mode to enter depending on voltage requirements.   Charge Mode The BCM will enter Charge Mode when ever one of the following conditions are met:   Windshield wipers are ON for more than 3 s. Climate Control Voltage Boost Mode Request is true, as sensed by the HVAC control module via serial data. High speed cooling fan, rear defogger, and HVAC high speed blower operation can cause the BCM to enter the Charge Mode. The estimated battery temperature is less than 0°C (32°F). Battery State of Charge is less than 80%. Vehicle speed is greater than 145 km/h (90 mph) A current sensor malfunction exists. System voltage is determined to be below 12.56 V When any one of these conditions is met, the system will set targeted generator output voltage to a charging voltage between 13.9–15.5 V, depending on the battery state of charge and estimated battery temperature.   Fuel Economy Mode The BCM will enter Fuel Economy Mode when the estimated battery temperature is at least 0°C (32°F) but less than or equal to 80°C (176°F), the calculated battery current is less than 15 A and greater than −8 A, and the battery state-of-charge is greater than or equal to 80%. Its targeted generator output voltage is the open circuit voltage of the battery and can be between 12.5–13.1 V. When fuel economy mode is active, the generator is not charging, only maintaining open circuit battery voltage. The BCM will exit this mode and enter Charge Mode when any of the conditions described above are present.   Headlamp Mode The BCM will enter Headlamp Mode when ever the head lamps are ON (high or low beams). Voltage will be regulated between 13.9–14.5 V.   Start Up Mode When the engine is started the BCM sets a targeted generator output voltage of 14.5 V for 30 s.   Tow/Haul Mode (if applicable) Pressing the Tow/Haul Mode button located on the center stack, the vehicle system voltage is raised and the remote (non-vehicle) battery will be charged. Having the headlamps on will raise the system voltage and if the Tow/Haul button is applied it will not serve any purpose. The voltage is regulated between 13.9-14.5 V.      
  • GM-Trucks.com Clubs

  • Popular Contributors

×
×
  • Create New...