Jump to content

Transmission overheating

dsm1995gst

By dsm1995gst
in Engines & Drivetrain

 Share

Recommended Posts

dsm1995gst Enthusiast

dsm1995gst

Posted
Posted

So I just got a new boat (only 17ft fiberglass) and was on the way to put it in the water for the first time and my 2018 GMC Z71 with 10k miles apparently can’t handle that, as within about 15 miles on the interstate I get a warning saying my transmission is overheating and I need to pull over and idle.

 

After a couple of minutes I was finally able to navigate through the control panel it said the trans temp was 258 degrees.

 

I was driving in tow mode.

 

After it cooled down to 210 degrees I tried again without tow mode and it was back to 241 degrees before I got to the next exit about 2 miles away.

 

Needless to say I’m pissed off.

  • Replies 33
  • Created
  • Last Reply

Top Posters In This Topic

Popular Days

Top Posters In This Topic

Popular Days

Popular Posts

flyingfool
flyingfool

you need to remove the trans thermostat

CamGTP
CamGTP

I'd take to the dealership with the boat, drive it with a tech and show them. Something that would be covered under warranty no doubt.

Farmerman1379
Farmerman1379

Did a quick Google search and found a thread on this site of another 2 people having the same issue with the thermostat not opening.

Farmerman1379 Enthusiast

Farmerman1379

Posted
Posted

How heavy is your boat? I can't imagine it overheating from that, especially if you're cruising interstate speeds with that air flow through the cooler.

CamGTP Senior Enthusiast

CamGTP

Posted
Posted

I'd take to the dealership with the boat, drive it with a tech and show them.


Something that would be covered under warranty no doubt.

  • Like 1
BlancoSilverado Enthusiast

BlancoSilverado

Posted
Posted
17 minutes ago, CamGTP said:

I'd take to the dealership with the boat, drive it with a tech and show them.


Something that would be covered under warranty no doubt.

Yup took the words out of my mouth, take it to the dealer. the thermostat might not be working.

Farmerman1379 Enthusiast

Farmerman1379

Posted
Posted
10 minutes ago, BlancoSilverado said:

Yup took the words out of my mouth, take it to the dealer. the thermostat might not be working.

Did a quick Google search and found a thread on this site of another 2 people having the same issue with the thermostat not opening.

  • Like 1
dsm1995gst Enthusiast

dsm1995gst

Posted
  • Author
Posted
Did a quick Google search and found a thread on this site of another 2 people having the same issue with the thermostat not opening.

Could it still be the thermostat if it doesn’t do it when not pulling the boat?

We ended up unhooking the trailer (and swapping trucks) and my truck drove home without the boat in the 195 degree range.
dsm1995gst Enthusiast

dsm1995gst

Posted
  • Author
Posted
How heavy is your boat? I can't imagine it overheating from that, especially if you're cruising interstate speeds with that air flow through the cooler.

I’m guessing like 1600 for the boat, 400 for the motor.


Sent from my iPhone using Tapatalk
dsm1995gst Enthusiast

dsm1995gst

Posted
  • Author
Posted

Just for reference, father-in-laws 2500 pulled the little boat with the transmission temperature at a cool 185 degrees...


Sent from my iPhone using Tapatalk

dsm1995gst Enthusiast

dsm1995gst

Posted
  • Author
Posted
Just for reference, father-in-laws 2500 pulled the little boat with the transmission temperature at a cool 185 degrees...


Sent from my iPhone using Tapatalk

And thus far today my truck has hit 210 driving around town... supposed to take it to the dealership tomorrow morning.


Sent from my iPhone using Tapatalk
HeySkippyDog Senior Enthusiast

HeySkippyDog

Posted
Posted

And thus far today my truck has hit 210 driving around town... supposed to take it to the dealership tomorrow morning.


Sent from my iPhone using Tapatalk
That is too high. I live in Central Florida and our ambient air temp is about 85-93F, and I am usually between 185-190F. Your transmission thermostat is probably stuck shut.

Sent from my SAMSUNG-SM-J727A using Tapatalk

BlancoSilverado Enthusiast

BlancoSilverado

Posted
Posted (edited)
On 7/22/2019 at 8:45 AM, dsm1995gst said:


And thus far today my truck has hit 210 driving around town... supposed to take it to the dealership tomorrow morning.


Sent from my iPhone using Tapatalk

What did the Dealer say?

 

Sorry, I jumped the gun.

Edited by BlancoSilverado
truckguy82 Senior Enthusiast

truckguy82

Posted
Posted (edited)
On 7/19/2019 at 6:37 PM, dsm1995gst said:

 

So I just got a new boat (only 17ft fiberglass) and was on the way to put it in the water for the first time and my 2018 GMC Z71 with 10k miles apparently can’t handle that, as within about 15 miles on the interstate I get a warning saying my transmission is overheating and I need to pull over and idle.

 

After a couple of minutes I was finally able to navigate through the control panel it said the trans temp was 258 degrees.

 

I was driving in tow mode.

 

After it cooled down to 210 degrees I tried again without tow mode and it was back to 241 degrees before I got to the next exit about 2 miles away.

 

Needless to say I’m pissed off.

 

I am the first person I know of to have a stuck closed trans thermostat. You’re doesn’t sound like that.

 

I also towed and even raced once while towing 4klbs (before I knew my trans thermostat was stuck closed)

 

-My temperature never increased anywhere close to as fast as yours

-it never got above 230, that’s towing 3k lbs through the city of philadelphia for an hour

 

So here’s how to tell if your thermostat is stuck.

 

Thermostat opens at 190-200. when your trans temp is like 140-160 range, pop your hood, and feel the drivers side trans cooler line in the front of the truck. Then feel the passenger side.

 

If your thermostat is stuck closed, your driver side line will be about as hot as your trans temp says it is. Your passenger side line will be ambient temp until the trans reaches 190-200. Once it reaches target temp the flow gates should open and the passenger side should be nearly as hot as the driver side.

 

if you have trouble located the lines, you can follow them right out of the transmission. It’s just easier to check them at the trans cooler since you don’t need to get under the truck

 

the techs had never dealt with this and were stumped. I had to basically figure this out on my own and verify the thermostat wasn’t operating and then tell them to change it.

 

Oh and btw you need to change all your trans fluid out it’s burnt.

 

Edited by truckguy82
  • Thanks 1

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now
 Share
Go to topic listing

  • Latest Articles

  • Posts

    • KARNUT
      OCI, not when but why?

      By KARNUT · Posted

      Well if you insist.
    • diyer2
      OCI, not when but why?

      By diyer2 · Posted

      You have to have the last word. 
    • Chuck FB
      summer road trips in the 2026 2500HD

      By Chuck FB · Posted

      I am sure that was quite the pass experience and not a great place to experience during the winter when the conditions are not good. I've seen video of that pass and also more detailed information and pictures about the wrecks at that one hair pin turn where tractor trailers have flown right off the cliff and I am sure from all the warning signs that you know the exact curve that was !. After all there is a reason why a song was made about Wolf Creek Pass !. By the way and I didn't realize this either when I bought my truck as its nothing I even thought of that would be programmed into the cruise control and this occurs in either the basic or the more advanced cruise that controls your distance behind a vehicle and that is the brakes going down a hill are being applied as soon as the vehicle goes a certain speed over the set cruise speed. While it certainly does force downshifts in the transmission as you found out with cruise on while going down hill, its also dragging the brakes as needed to keep the speed controlled to what the cruise was set to. For me, I find that unsettling simply because I have no concept then as to how MUCH brake input is being used a and just how hot are those brakes getting and the wear factor as well. I can see that system getting a person into trouble on long mountain grades while pulling a trailer as it would not only be standing on the brakes of the pickup without any driver input, it would also be automatically applying the trailer brakes and it could cause a run away unit by overheating the brakes. Its one thing on a shorter hill and if the driver allows it to do its thing but on a long mountain grade is where things could get so out of hand. As someone a while back on this forum said, they had someone following them at night I believe on a down grade and had the cruise set and the person behind them could see the brake lights being energized all the way down the hill. I figured when I saw your comment that you didn't know and would have no way of knowing that your truck was applying the brakes and that you would and rightfully so assume you only used the brakes when you pressed on the pedal to slow down more than the cruise set speed for the slower sharp curves. So its good knowledge to know this about the newer GM trucks, certainly when doing any descending on long mountain grades. In the future try kicking off the cruise and use the the manual mode on a pass to see what that is like as I know myself when I first experienced it I thought no way can this engine be holding me back this well and tried the same hill in manual mode and sure enough the engine was revving way up and still could not hold the trucks speed down like it could in cruise mode.    Fuel mileage, that is where a really low sleek type of car can do better at higher speeds, certainly it starts sucking fuel too but a tall pickup is pushing massive amounts of air and also allowing a lot more air under it and the tow mirrors as in elephant ears pushing through the wind  as well. Driving like grandpa is about as good as one can do when driving one of these if trying to get the best fuel economy they can. I bet these trucks would get the best mileage they can if driven on a freeway in Florida if not busy traffic at a sedate speed and that sea level elevation without hills, vastly different then Colorado !. 
    • KARNUT
      OCI, not when but why?

      By KARNUT · Posted

      It’s over for almost 24 hours. Are you playing Eddie Haskell? 
    • diyer2
      OCI, not when but why?

      By diyer2 · Posted

      Again, really you two.

  • GM-Trucks.com Clubs

  • Popular Contributors

×
×
  • Create New...