Jump to content

2024 Brake controller Problems

Curt Lowe
 Share

Recommended Posts

Jettech1 Senior Enthusiast

Jettech1

Posted
Posted
On 9/29/2023 at 10:33 AM, Rototerrier said:

Your vehicle is charging the batteries while you are towing.

Yes it is, most people don't know that.  When we dry camp overnight at say a Walmart parking lot on our way to another campground, the battery is at a 100% when we stop and typically around 65% when we leave the next morning 10 hours later.  The battery on the camper is keeping our fridge and freezer cold.  It's giving us light, powering up our phones, powering the water pump when we take showers, that one battery is doing it's job big time.  After driving another 3 hours when we stop to stretch, I look at the power meter and we are back to 100% just from the truck and our 165 watt solar panel.  I love it!!!

  • Replies 229
  • Created
  • Last Reply

Top Posters In This Topic

Popular Days

Top Posters In This Topic

Popular Days

Popular Posts

Kyleb100
Kyleb100

I have the same issue with my 2024 sierra 3500. I get the “check trailer wiring” “service trailer brake system” intermittently. I spent $700 bucks to have the entire trailer re-wired from the pigtail

Rototerrier
Rototerrier

Good news. Disconnected Solar and for the first time ever i didn’t receive a check trailer wiring error when hooking up. Did a 20 mile loop without any issues. Will have to see what happens on my next

UWSkier
UWSkier

I've ordered a diode I'm going to put into the 12v line so the trailer can't push any voltage back to the truck.  Hope to do that, reconnect solar, then go for a drive to see if it fixed my problem.

Posted Images

Kevin Peele New Member

Kevin Peele

Posted
Posted (edited)

Just had to cancel a vacation from Iowa to Maine because of this. The truck threw these errors and I suspected the solar causing it. disconnect it (2 hr into trip) in Illinois and all was fine for the another coupe of hrs. then in Indiana started again intermittently. decided better to cancel trip. after awhile it only disengaged when starting the truck.   

Edited by Kevin Peele
broken link
Kevin Peele New Member

Kevin Peele

Posted
Posted
On 8/27/2023 at 11:00 PM, UWSkier said:

My truck goes in on Tuesday for service.  Hoping they have the bulletin published by then so I can point the service director to that.  Also need them to figure out why any trailer I plug in says the running lights don't work, and the running lights are always on.  Will update what I hear.

Ah you have the running light problem too? I took it in to Chevy and it's supposed to be a "trailer light module" they need to order a part which they cannot get because of the strike. But I am also having the trailer brake issue as well.

2Ranchers Enthusiast

2Ranchers

Posted
Posted
17 hours ago, Jettech1 said:

Yes it is, most people don't know that.  When we dry camp overnight at say a Walmart parking lot on our way to another campground, the battery is at a 100% when we stop and typically around 65% when we leave the next morning 10 hours later.  The battery on the camper is keeping our fridge and freezer cold.  It's giving us light, powering up our phones, powering the water pump when we take showers, that one battery is doing it's job big time.  After driving another 3 hours when we stop to stretch, I look at the power meter and we are back to 100% just from the truck and our 165 watt solar panel.  I love it!!!

This is true but, it does not charge with a high enough voltage (14.6-.8) volts to fully equalize a LiFePo4 battery(s) which is important for long battery life. You need a LiFePo4 enabled solar charge controller or a proper DC converter to get to the required voltage. 

Jettech1 Senior Enthusiast

Jettech1

Posted
Posted
1 hour ago, 2Ranchers said:

This is true but, it does not charge with a high enough voltage (14.6-.8) volts to fully equalize a LiFePo4 battery(s) which is important for long battery life. You need a LiFePo4 enabled solar charge controller or a proper DC converter to get to the required voltage. 

I just have a run of the mill lead acid battery.  When it dies I'll be switching to Lipo.  Our camper is already equipped with a selectable charge controller for the different battery types.

  • Like 1
UWSkier Enthusiast

UWSkier

Posted
Posted
3 hours ago, Kevin Peele said:

Ah you have the running light problem too? I took it in to Chevy and it's supposed to be a "trailer light module" they need to order a part which they cannot get because of the strike. But I am also having the trailer brake issue as well.

Yes.  Waiting on the two modules.  One is in.  Other is supposed to arrive tomorrow, but I doubt that...

Kevin Peele New Member

Kevin Peele

Posted
Posted
2 hours ago, UWSkier said:

Yes.  Waiting on the two modules.  One is in.  Other is supposed to arrive tomorrow, but I doubt that...

Wait what? waiting on parts since end of Aug? good grief.

UWSkier Enthusiast

UWSkier

Posted
Posted (edited)
17 hours ago, Kevin Peele said:

Wait what? waiting on parts since end of Aug? good grief.

I have a 2024.  It was diagnosed as needing a new trailer light control module in addition to the updated brake control module at the dealership two weeks ago, which is when they ordered the modules.  Computer still saying the light module will arrive today.  It's scheduled to go in for service tomorrow.

Edited by UWSkier
Jon Sairs New Member

Jon Sairs

Posted
Posted

 I am so glad I found this thread. I am on a sunny road trip with my 2024 3500  Duramax which is  is disconnecting it's trailer controller and chimming constantly as I tow my TT with 300 watts solar  & 1.000 miles to go!!!

I will try disconnecting solar and or  removing #84 fuse and try to keep my sanity! I will give an update to see if this cures the issue.

Interestingly the last trip was cloudy and I did not have this issue.

UWSkier Enthusiast

UWSkier

Posted
Posted
22 hours ago, Jon Sairs said:

 I am so glad I found this thread. I am on a sunny road trip with my 2024 3500  Duramax which is  is disconnecting it's trailer controller and chimming constantly as I tow my TT with 300 watts solar  & 1.000 miles to go!!!

I will try disconnecting solar and or  removing #84 fuse and try to keep my sanity! I will give an update to see if this cures the issue.

Interestingly the last trip was cloudy and I did not have this issue.

Turning off the solar will help but you still might see it briefly from time to time.  At least that was my experience before I bought a cheap diode and wired it in.

2Ranchers Enthusiast

2Ranchers

Posted
Posted

Brought the truck in for its first oil change (complementary) and told the dealer about the brake controller issue when towing our travel trailer. They've ordered a new updated brake controller. No commitment to when it will arrive sue to the strike.

 

2Ranchers Enthusiast

2Ranchers

Posted
Posted

New brake controller arrived today. Bringing the truck in next week for install and re-programming. 

Shocked that it took only 5 days to get here.

 

  • Like 1
UWSkier Enthusiast

UWSkier

Posted
Posted
On 10/2/2023 at 10:21 AM, Kevin Peele said:

Ah you have the running light problem too? I took it in to Chevy and it's supposed to be a "trailer light module" they need to order a part which they cannot get because of the strike. But I am also having the trailer brake issue as well.

both modules swapped out and both problems fixed!

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now
 Share
Go to topic listing

  • Latest Articles

  • Posts

    • Another JR
      Gasser Subforum Has Been Quiet - - So, Regenerative Braking and Using L10

      By Another JR · Posted

      Have considered installing a DC to DC charger in your camper to replace your isolator?  
    • newdude
      Gas fill door

      By newdude · Posted

      Common failure.  You need to replace the fuel door housing.   The painted cover transfers over to the new housing.  To remove the old one there is 4 spots where you poke the plastic to release it.  
    • newdude
      Gasser Subforum Has Been Quiet - - So, Regenerative Braking and Using L10

      By newdude · Posted

      No such thing as regenerative braking on a pure ICE vehicle.     Regenerative braking is the re-capture of energy from electric motors and stores it in the battery pack.  So hybrids, PHEV and EVs have regenerative braking.     What you are seeing is the charging system changing modes is all.  Its likely entering charge mode for some sort of reason is all.  All of the charging modes will be listed below.   As for L10 vs D.  L10 turns off automatic grade braking.  L10 puts you in control of grade downshifts where in D it will automatically do it based on brake pedal position and other factors.  Otherwise L10 and D drive exactly the same aside from that one aspect.    Battery Sulfation Mode The BCM will enter this mode when the interpreted Generator output voltage is less than 13.2 V for 45 minutes. When this condition exists the BCM will enter Charge Mode for 2–3 minutes. The BCM will then determine which mode to enter depending on voltage requirements.   Charge Mode The BCM will enter Charge Mode when ever one of the following conditions are met:   Windshield wipers are ON for more than 3 s. Climate Control Voltage Boost Mode Request is true, as sensed by the HVAC control module via serial data. High speed cooling fan, rear defogger, and HVAC high speed blower operation can cause the BCM to enter the Charge Mode. The estimated battery temperature is less than 0°C (32°F). Battery State of Charge is less than 80%. Vehicle speed is greater than 145 km/h (90 mph) A current sensor malfunction exists. System voltage is determined to be below 12.56 V When any one of these conditions is met, the system will set targeted generator output voltage to a charging voltage between 13.9–15.5 V, depending on the battery state of charge and estimated battery temperature.   Fuel Economy Mode The BCM will enter Fuel Economy Mode when the estimated battery temperature is at least 0°C (32°F) but less than or equal to 80°C (176°F), the calculated battery current is less than 15 A and greater than −8 A, and the battery state-of-charge is greater than or equal to 80%. Its targeted generator output voltage is the open circuit voltage of the battery and can be between 12.5–13.1 V. When fuel economy mode is active, the generator is not charging, only maintaining open circuit battery voltage. The BCM will exit this mode and enter Charge Mode when any of the conditions described above are present.   Headlamp Mode The BCM will enter Headlamp Mode when ever the head lamps are ON (high or low beams). Voltage will be regulated between 13.9–14.5 V.   Start Up Mode When the engine is started the BCM sets a targeted generator output voltage of 14.5 V for 30 s.   Tow/Haul Mode (if applicable) Pressing the Tow/Haul Mode button located on the center stack, the vehicle system voltage is raised and the remote (non-vehicle) battery will be charged. Having the headlamps on will raise the system voltage and if the Tow/Haul button is applied it will not serve any purpose. The voltage is regulated between 13.9-14.5 V.      
    • jaszr2
      Active Grille Delete

      By jaszr2 · Posted

      Hello from Australia Just sharing that there is now a way to delete the active shutters entirely with just a plug in module. Opens up tons of room to light bars etc.
    • jake111
      Gasser Subforum Has Been Quiet - - So, Regenerative Braking and Using L10

      By jake111 · Posted

      I have an observation and a question... 1) I watch the voltage closely because I have had to dial in the cut-in/cut-out voltages of the battery separator to my camper.  The "smart" charging drives me nuts.  Anyway, I noticed that when coasting for a while, and especially if lightly using the brakes (though not necessary), the voltage goes up from mid/high-13 volts to mid/high-14 volts.  Then it drops back down after stopping or going again.  Consistently!   The only explanation I can come up with is REGENERATIVE BRAKING!  Well, maybe that's a little bit of an exaggeration, but it's certainly free extra battery charging.   2) Driving on mountain roads I will use L and vary the max gear.  Things straighten out and I end up in L10.  Sometimes I leave it there for a while.  Is there any difference between L10 and D?   

  • GM-Trucks.com Clubs

  • Popular Contributors

×
×
  • Create New...