Jump to content

Looking for better MPG

jorswift
 Share

Recommended Posts

jorswift Enthusiast

jorswift

Posted
Posted (edited)

Have a 2015 sierra 1500 5.3. Bought truck several years ago with 70k miles. Now with having to return back to office, I am over 100k. Truck is mainly stock, but have some 33" tires and leveling kit. With having to drive a ton more now and filling up more often, I am looking to do somethings to get better MPG. Truck seemed to get good mileage when I first bought it around the 70k mark.Any advice? Thanks.

Edited by jorswift
  • Sad 1
Silverado4x4 Senior Enthusiast

Silverado4x4

Posted
Posted
37 minutes ago, jorswift said:

Have a 2015 sierra 1500 5.3. Bought truck several years ago with 70k miles. Now with having to return back to office, I am over 100k. Truck is mainly stock, but have some 33" tires and leveling kit. With having to drive a ton more now and filling up more often, I am looking to do somethings to get better MPG. Truck seemed to get good mileage when I first bought it around the 70k mark.Any advice? Thanks.

Get rid of the 33s and go back to stock size and remove the leveling kit. The leveling kit raises the front and creates more wind drag and the 33s are heavier than the stock tires which take more power to keep them rolling, rolling resistance. 

  • Like 5
scrapen Enthusiast

scrapen

Posted
Posted

With stock tire size expect around maybe 18 mpg.  So if you average 16-17 I’d say it’s normal.  If you haven’t done plugs there’s a good chance they’ve never been done.

 

personally if you’re putting on a lot of miles a beater car can pay itself off.  My diesel vw is averaging 49 mpg (.08 per mile last 8 years vs .19 per mile on my truck (tuned for 91)). I’ve kept over 50k miles off the truck which now sits at 42k.

  • Like 1
jorswift Enthusiast

jorswift

Posted
  • Author
Posted

Yeah, not looking to see "great" results. Just something a little better I guess. I know the level and tires would kill it, but at that time I was not driving that much. Thinking of a tuner to calibrate tires and get the 87 tune.

mikeyk101 Senior Enthusiast

mikeyk101

Posted
Posted

Another thing that may be affecting your gas mileage is regarding the 33" tires. Just curious if you corrected your speedometer? I'm not 100% sure but believe the speedometer is probably linked with the odometer. With larger sized tires, if speedo not corrected, it will show you are going slower than you are. So that would translate into showing you are covering less ground than you are. So if you are covering less ground but still using the same amount of fuel, it will obviously look like you are getting less mpg than you really are. 

  • Like 1
  • 2 weeks later...
newdude Senior Enthusiast

newdude

Posted
Posted

Are they 33" aggressive tires?  Or 33" highway tread?  Are they flotation size so like 33x12.5x20?  

 

Going up in diameter, sure you'll see MPG change but the weight and tread design and if its a tire size like I mentioned has much more effect here than them being 33" diameter.  

  • Like 3
diyer2 Senior Enthusiast

diyer2

Posted
Posted

Stock size tires, remove lift. Best mileage you'll get.

  • Like 1
Z45 Senior Enthusiast

Z45

Posted
Posted (edited)
On 8/14/2025 at 10:25 AM, jorswift said:

 Thinking of a tuner to calibrate tires and get the 87 tune.

More $ wasted chasing a dream.   You are still pushing 2.5 tons of steel down the road.  Put the truck back to 100% stock if you really want to keep it, but spending money to get better mileage is a pipe dream.  Spend 100's to save pennies.  

Edited by Z45
  • Like 4
  • Thanks 1
Grumpy Bear Senior Enthusiast

Grumpy Bear

Posted
Posted
On 8/14/2025 at 6:31 AM, jorswift said:

Have a 2015 sierra 1500 5.3. Bought truck several years ago with 70k miles. Now with having to return back to office, I am over 100k. Truck is mainly stock, but have some 33" tires and leveling kit. With having to drive a ton more now and filling up more often, I am looking to do somethings to get better MPG. Truck seemed to get good mileage when I first bought it around the 70k mark.Any advice? Thanks.

 

1.) Lower and stock size H/T tires. Already said. Goes to frontal area and rolling resistance. Oh and run those tires hard. Adding 3 psi over nameplate will not kill the tire nor the wear if the alignment is correct. 

2.) Alignment. Tires standing up near zero camber but negative, -.2 to 0 and even. Toe positive, even and minimum, .02-.04. Shoot for zero steer-ahead and zero thrust angle. And take some caster out of it but stay in spec. 

3.) Tune up and not a tune. Standard stuff. Plugs, wires air filter. PVC system. 

4.) Minimum weight. That stuff in the bed/cab you don't use, ditch it.

5.) Soft tonneau cover and keep the gate up. 

6.) You'll love this one...Slow down. Drive like you haven't any brakes. It's an art. Anticipate lights and traffic. Yea, it takes a few more minutes so start earlier. I'm not talking snails pace but even 10 mph make a HUGE impact. At least the speed limit. Get used to being passed but not a a$$. 

7.) Scan Gauge III. You'll be surprised how much instant real time feed back corrects bad habits. Hones point #6. 

8.) Stay out of the drive through. 

9.) Pan heater in the winter. Cold oil is the big end of the winter fuel economy loss. On trips as long as yours 0W* oil gives you next to nothing over 5W* and use a 'slick oil' Lubricity is huge. And not all 0W or 5W oils are created equal. The cold weather properties of the specs are MAXIUMS not minimums and those that use PAO's instead of Group III at the bulk base will always have lower CCS numbers. I'll let you fret the brand. 

 

  • Like 3
  • Thanks 1
JimCost2014 Senior Enthusiast

JimCost2014

Posted
Posted

Not to be a complete smart-ass, but park it in the garage and get a small commuter car. A V-8 truck is only going to get a certain MPG, no matter what you do. If you believe the stories of 30++ mpg members are getting, you are going to be disappointed with your results.

  • Like 2
  • Thanks 1
Grumpy Bear Senior Enthusiast

Grumpy Bear

Posted
Posted
12 hours ago, JimCost2014 said:

Not to be a complete smart-ass, but park it in the garage and get a small commuter car. A V-8 truck is only going to get a certain MPG, no matter what you do. If you believe the stories of 30++ mpg members are getting, you are going to be disappointed with your results.

 

One has little to do with the other. That said and in a more liberal meaning; it is wise to compare only to yourself. Perhaps that was the intent.

 

If you think you can't get a 15-20% improvement, you'd be mistaken. Go all in and 30% is not off the table. Pepper is not a "Story", the results were the results hand calculated and graphed. Everyone got to follow along in 2019 were for the year it tapped 30+ mpg. The items on the list I put up were the ones I used to get that result. In print in my build thread. 

 

Can I do that with a four door V8? 30 mpg? No. But I can get one to respond to the physics involved as can anyone else that honestly tries and applies the science.

 

As for the other suggestion. Yes. And if you won't believe 30+ with a pickup you will never get your head around 52+ mpg in a Mitsubishi Mirage for it's first year.

 

30,173 miles in year one using 578.75 gallons of fuel = 52.13 mpg RESULT. 718 engine hours = 42 MPH RESULT

13 mpg over the EPA combine value. 33% improvement! 6 mph faster than that national average. Rinse and repeat or Pepper using exactly the same methods to get exactly the same results. Quite a story. 

 

EPA numbers: The Mitsubishi Mirage has an EPA fuel economy rating of up to 36 miles per gallon in the city and 43 miles per gallon on the highway, averaging around 39 miles per gallon combined. 

 

 

  • Like 2
asilverblazer Senior Enthusiast

asilverblazer

Posted
Posted

I was never able to get a commuter car to pencil out. 

 

Starting at a modest 5000.00 for the car price, plus its own maintenance, registration, insurance and gas. Never even comes close to saving me money. 

 

Going up on the 5000.00 so that I'm not spending my commute in an absolute $hitbox only makes it worse. 

 

MY math, assuming I ONLY drive the commuter and don't drive my truck AT ALL, with some simple rounding... 

18000 mile per year in the truck averaging 17 mpg = 1050 gallons of diesel at $3.10 per gallon = $3300.00 per year.

In a car that gets 30 mpg = 600 gallons of gas at $2.75 = $1650.00 per year. 

I would be saving about $1650.00 in fuel costs.

From that savings I have to buy the car and pay the above continual expenses. $150.00 in oil changes, $100.00 in registration, $600.00 in insurance, assume no other repairs are needed (unlikely given we're trying to save money on the car) leaves $800.00 per year in savings. If I buy the car at the above $5000.00 price it would take over 6 years to realize any savings, at which point, the car will need tires and other maintenance costs that would likely push the savings point out to over 7 years. 

 

Raising the purchase price to lower the maintenance cost or lowering the purchase price would raise the maintenance amount... never going to work for me. 

 

OP's 30k miles in "several years" doesn't sound like an amount of miles that would push this equation to a point that make sense for him either. 

 

In broader terms this is why truck owners DO CARE about mpg, so many say "you bought a truck it won't get good gas mileage... you should have bought a car..." don't understand that some people drive to a job Monday through Friday and have other responsibilities or activities that require a truck on the weekend. Having two separate vehicles for this doesn't make sense based on the dollars above. 

  • Like 2
  • Thanks 2
swathdiver Senior Enthusiast

swathdiver

Posted
Posted
On 8/14/2025 at 7:31 AM, jorswift said:

Have a 2015 sierra 1500 5.3. Bought truck several years ago with 70k miles. Now with having to return back to office, I am over 100k. Truck is mainly stock, but have some 33" tires and leveling kit. With having to drive a ton more now and filling up more often, I am looking to do somethings to get better MPG. Truck seemed to get good mileage when I first bought it around the 70k mark.Any advice? Thanks.

 

Keep up with the maintenance and slow down.  That's all you can really do without spending money.  

 

Big truck = safety

  • Like 3

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now
 Share
Go to topic listing

  • Latest Articles

  • Posts

    • Atlas
      Tire psi

      By Atlas · Posted

      It's possible the two trucks are using different body control modules which is why yours works and the OP's doesn't.   So much in these newer vehicles depends on model/trim configurations, production date. They don't all use the same modules like back in the day.
    • Chuck FB
      Tire psi

      By Chuck FB · Posted

      I forgot to answer the question as per what market mine is set to and yes I finally found that area on mine and yes its also set to America.   So here's something I realized as I wasn't looking at that part in the Sierra section until now, your right that what I see here as choice 3 under Sierra which says 07/2023-06/2026 ( 433 MHz 13542523 ) it has no choice 5 for tire pressure selection. Where as it does under the Chev choice. However I kept going down the list within the Sierra and I am really wondering if choice 9 will work for your truck as it has the same model number and hertz sensor as my truck. I would say try that choice first, if that doesn't work then jump over to the Chev section and again choose that same model and hertz choice as for some reason the Chev section gives the choice 5 of tire type/pressure selection for going back a number of years. Could very well be an Autel thing that they just didn't get the updates all done properly under Sierra but anyway first try that selection 9 I suggested under Sierra and then go from there. 
    • B07
      Anyone have a spare?

      By B07 · Posted

      Looking for this piece that holds the hose clamp in place. I have the hose clamp just not that other piece. Dealers and wrecking yards in my area will not sell just that piece. They want you to buy the whole air tube $100 +/- to get that $5 part.  that piece isn't molded to the air tube as I looked at my friends truck. It's held on by a screw and nut. I'm trying to put the OEM parts on the truck as the previous owner butchered things up installing an aftermarket CAI. It really looked homemade. 🤣 Thanks
    • Chuck FB
      Tire psi

      By Chuck FB · Posted

      Ok I missed that part that yours is a GM. The strange part is that the choice for year ranges and within the year of 2026 is different on the Sierra then on the Chev for some reason as I am looking at my tool at the Sierra choices. Now I am guessing you see as to your sensor part number as it may be different on your truck for some reason and a call to GM should get you the part model number of the sensors you should have as well as which MHz your sensors are. I know mine are the ones as per what I listed but there are other choices in the Autel and got me wondering if by some chance they put different ones in your truck. Having said that, did you try using each of the choices starting from No 1 and going on down the list, not sure if that would mean shutting off the engine each time and resetting the tool and going at it again each time. Also I thought of something else which may sound retarded but if there was some stupid chance that the chev choice would work. The reason I say that is that the Sierra is showing a range up to 06/2026 for the various choices of sensors it could be where as the Chev has one choice that has that 12/2026. By the way it is possible to not run the truck and you may know that as per not pressing the brake but pressing and holding the start button for a few seconds and it lights up the dash ( its called service mode ) but that sucks battery power and if it were me doing it that way I would be throwing on a decent sized battery charger before doing it that way as killing your battery won't make you happy at me at all !.    Like I say, just a thought to try the Chev choices if you have already exhausted the Sierra choices but first it would be nice to know for sure what exact sensor model and hertz your truck uses as I assume only those choices that mention the sensor would work unless a choice that does not mention the sensor model would somehow work. Its frustrating when one is trying to use tools like this without the experience of the tool and the vehicle, as I am sure dealer techs themselves struggle with it when starting out or a new model year comes along that is slightly different. 
    • jgaudet99
      Tire psi

      By jgaudet99 · Posted

      I tried before I updated the scan tool just incase an update messed it up, but it never worked so I updated the scan tool and it still didn't work.   Only difference is I click on Sierra not Chevrolet cause I have a Sierra.   If I click on 2026-2024 I didn't have any option to change placard, when I click on 2023 it does give me the option but when I try to do it,.it says vehicle not supported!   I have my region or market or whatever it is set to America I think, is that what yours is set to?

  • GM-Trucks.com Clubs

  • Popular Contributors

×
×
  • Create New...