Jump to content

Recall - Vacuum Pump May Decrease Power Brake Assist

Retired Bob
 Share

Recommended Posts

Sierra Dan Senior Enthusiast

Sierra Dan

Posted
Posted

This recall however does not take care of the known faulty Vacuum Pump. Faulty Pump recall came about a few months back where they replace the pump if

a loss of braking power is detected. 

This software update is a band aid quicker and cheaper fix than replacing the root problem.

Aside from a possible loss in braking power...……..when the pump goes, it causes metal shavings to enter the oil system thus possibly grenading the engine.

Which is another good reason for replacing the newer upgraded Vacuum Pump.

 

  • Replies 206
  • Created
  • Last Reply

Top Posters In This Topic

Popular Days

Top Posters In This Topic

Popular Days

Popular Posts

camcamaro1991
camcamaro1991

As a former discount tire employee (days of 5 were hired and only 3 could keep their job, today auditions are gone), started back in the firestone/ford recall days, and later becoming a MB Master tech

jay webb
jay webb

ok the special coverage is for a faulty vacuum pump which is a mechanical pump attached to the engine. this is not a  recall. the recall is a reprogram of the EBCM software. two separate things. now i

Mike GMC
Mike GMC

So now we need an extended warranty on the ABS unit to cover premature wear from using it in normal braking?  Seems like yet another band aide to me.  That Corvette electric pump is looking better and

Posted Images

KARNUT Senior Enthusiast

KARNUT

Posted
Posted

Seems all the V-8s I owned didn’t have to this problem prior to the 14 model. Without much research I bought my 14. After joining this forum and learning about cylinder deactivation and all it involves I unloaded it. I was having flashbacks to the 5.7 diesel. External vacuum pump, what the hell. I’m done with new GMs unless they use a normal engine again.


Sent from my iPhone using Tapatalk

dsatwork Enthusiast

dsatwork

Posted
Posted

I just got back from towing my 27' Airstream with my heavily loaded 2015 Silverado 5.3 1500 3.73 from San Diego to (Show Low) White Mountains in AZ via the Salt River Canyon and had to brake hard once with the trailer and once without the trailer on this trip and neither one felt right. First I thought it was because of the heavy load, but when it happened empty without the trailer, it made me wonder if there was an issue. The only other factor was that I had the brake lines flushed just before I took off, so at first it felt a little funny because of that as well. Regardless, I'm scheduled to get the system reprogramed next week before I head up to Idllywild for the weekend. Don't use my brakes much when towing and depend on the Tow Haul mode to keep me safe coming down 6% grades. 

1SLOW1500 Senior Enthusiast

1SLOW1500

Posted
Posted
I just got back from towing my 27' Airstream with my heavily loaded 2015 Silverado 5.3 1500 3.73 from San Diego to (Show Low) White Mountains in AZ via the Salt River Canyon and had to brake hard once with the trailer and once without the trailer on this trip and neither one felt right. First I thought it was because of the heavy load, but when it happened empty without the trailer, it made me wonder if there was an issue. The only other factor was that I had the brake lines flushed just before I took off, so at first it felt a little funny because of that as well. Regardless, I'm scheduled to get the system reprogramed next week before I head up to Idllywild for the weekend. Don't use my brakes much when towing and depend on the Tow Haul mode to keep me safe coming down 6% grades. 
Sorry have to ask. Did you set up and use a trailer brake?

Sent from my SM-N960U using Tapatalk

dsatwork Enthusiast

dsatwork

Posted
Posted

Yes, and I keep the trailer brake screen on the dash front and center, when I first take off to make sure everything is connected. No offense taken, been on these forums long enough to know that the obvious isn't as obvious as you would think and hope.

dsatwork Enthusiast

dsatwork

Posted
Posted
1 hour ago, 1SLOW1500 said:

Sorry have to ask. Did you set up and use a trailer brake?

Sent from my SM-N960U using Tapatalk
 

Yes, and I keep the trailer brake screen on the dash front and center, when I first take off to make sure everything is connected. No offense taken, been on these forums long enough to know that the obvious isn't as obvious as you would think and hope.

  • Like 1
15 Z71 Senior Enthusiast

15 Z71

Posted
Posted

I had  got a letter saying they would extend the warranty for 6 years or 72,000 miles for this issue. My question is if I take it for this re program and have the pump go out down the road will they still repair it if I'm under the special coverage? Or should I just wait until my special coverage is getting closer to running  out? Or they going to try and say the re program is the fix the letter means nothing now?

16LT4 Enthusiast

16LT4

Posted
Posted
7 hours ago, TXGREEK said:

 


Discount Tire does it for free emoji6.png

 

Who the heck is that and why would I trust a high school drop out to touch my truck? Dealer provides 2 free rotations, so if convenient I’ll do them. 

 

I can rotate them for free too and do on my other 4, but the recall is the final impetus to drag myself the 5 miles down there to the dealer. 

TXGREEK Senior Enthusiast

TXGREEK

Posted
Posted
Who the heck is that and why would I trust a high school drop out to touch my truck? Dealer provides 2 free rotations, so if convenient I’ll do them. 
 
I can rotate them for free too and do on my other 4, but the recall is the final impetus to drag myself the 5 miles down there to the dealer. 


I assure you, a college degree is not required to change oil or change a tire lol. Sounds like you’ve got it all figured out
  • Like 2
Mikebtte Enthusiast

Mikebtte

Posted
Posted (edited)
11 minutes ago, TXGREEK said:

 


I assure you, a college degree is not required to change oil or change a tire lol. Sounds like you’ve got it all figured out

 

Haha, yup. If not for highschoolers I would never find technicians. 

I have gotten a few fresh out of trade school only to find out they wasted some money's.

Had one fresh out of school that was unable to change a belt.

If the shop does have a knowledgeable tech, you can bet he ain't doing tires. 

Edited by Mikebtte
Words.
  • Like 2
16LT4 Enthusiast

16LT4

Posted
Posted (edited)
16 minutes ago, TXGREEK said:

 


I assure you, a college degree is not required to change oil or change a tire lol. Sounds like you’ve got it all figured out

 

I never mentioned college?

 

I seldom let a “trained professional” do any work for me because it’ll always be more work for me to fix their mistakes. Some lackey moron touching my truck is asking for trouble; I know I’ll have to retorque my lugs when I get home, but at least the dealer has more to lose if something goes wrong, and my lift is occupied. 

Edited by dukedkt442
TXGREEK Senior Enthusiast

TXGREEK

Posted
Posted
I never mentioned college?
 
I seldom let a “trained professional” do any work for me because it’ll always be more work for me to fix their mistakes. Some lackey moron touching my truck is asking for trouble; I know I’ll have to retorque my lugs when I get home, but at least the dealer has more to lose if something goes wrong, and my lift is occupied. 


Most likely, same tech schools, Discount Tire is a fantastic company that I’ve brought my daily driver and exotic toys to throughout many years with zero issues.
  • Like 1
jay webb Enthusiast

jay webb

Posted
Posted
13 hours ago, 1SLOW1500 said:

I think you will find people will be cleaning and rebuilding the pumps in the future. Also doing line clearing to judge the health of the pump.

I know GM will not switch over, however the electric pumps found on the Corvette seem a better option.

Sent from my SM-N960U using Tapatalk
 

i have replaced two brake module/vacuum pump/booster assemblies on the 2019s already. its an all in one unit. the only part that is separate is the  fluid reservoir. they have software issues. its all electronic.  

jay webb Enthusiast

jay webb

Posted
Posted
1 hour ago, 15 Z71 said:

I had  got a letter saying they would extend the warranty for 6 years or 72,000 miles for this issue. My question is if I take it for this re program and have the pump go out down the road will they still repair it if I'm under the special coverage? Or should I just wait until my special coverage is getting closer to running  out? Or they going to try and say the re program is the fix the letter means nothing now?

ok the special coverage is for a faulty vacuum pump which is a mechanical pump attached to the engine. this is not a  recall. the recall is a reprogram of the EBCM software. two separate things. now i think gm is thinking if they change how the abs/ebcm uses the vacuum will prevent the pumps from wearing out. as a tech who has change 50ish of these pumps under special coverage i believe its a lack of proper oil changes, its attaches the engine and supplied oil from the oil system. people dont change their oil properly. wait til its says change oil soon/ or 0% or going 1000s of miles pass 0% oil life. I KNOW what is the point of the oil life monitor system? well its to inform you to change your oil but its based on software that uses an algorithm based on engine use/conditions. i have a 2018 sierra. i change my oil every 5000 i dont wait for the truck to tell me.  

  • Like 4
bkesting Enthusiast

bkesting

Posted
Posted
7 hours ago, Sierra Dan said:

This recall however does not take care of the known faulty Vacuum Pump. Faulty Pump recall came about a few months back where they replace the pump if

a loss of braking power is detected. 

This software update is a band aid quicker and cheaper fix than replacing the root problem.

Aside from a possible loss in braking power...……..when the pump goes, it causes metal shavings to enter the oil system thus possibly grenading the engine.

Which is another good reason for replacing the newer upgraded Vacuum Pump.

 

So there is a newer style pump? If so, is it hard to change out?

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now
 Share
Go to topic listing

  • Latest Articles

  • Posts

    • StingerZ16
      Roll up bed cover experiences

      By StingerZ16 · Posted

      I started with a folding cover by BAK PAC on my 2500. It went bad after close to 5 years. Bent and vinyl coming loose. Contacted BAK and they gave me a very good discount on a Revolver. Had it a number of years. Mostly outdoor storage. Some garage storage. Vinyl started to come loose. Still under warranty so they replaced to cover. Sold the 2500, bought the 1500 and got another revolver for it. Had it a couple years now and no issues. I store it indoors. Got a bit of discount when buying it as well. If you are seeing problems, contact BAK or real truck and let them know. Customer service was pretty good. But I think they changed their warranty.
    • Chuck FB
      Towing In Loose Gravel

      By Chuck FB · Posted

      I agree, there is no one answer fits all as every rig is different, one may be pulling some little aluminum fishing boat while another is towing a monstrosity that weighs a lot and hopefully the owner if the rig has some prior experience to know what drive mode they should choose.    It also struck me and this is from watching a few of those boat ramp escapades videos in the past, Ford being one of the vehicles that has the auto front axle hubs and sure enough its found out that one hub has crapped out and won't engage and may not have manual hubs to even select on both sides so they are on the boat ramp stuck with no four wheel drive and spinning .... they flat out need a tow to get up the ramp and deal with the vehicles new found issues. That can happen to all brands of pickup, finding out either four wheel drive or 4 low isn't working right at the time its needed it to work as some electronic crap has failed. 
    • Chuck FB
      Towing In Loose Gravel

      By Chuck FB · Posted

      Its possible you never had the joy of the crappy boat launches we tend to have around here or really some of them are just grades down to the river if its a river scenario and the conditions change all the time with the river levels and silt deposits. Some of the lakes we went to years ago, there was no such thing as a cement pad that went down into the water that the trailer stayed on, it was gravel maybe up to the water line and then duck crap much beyond that so sinking the boat tires into mud. Of course some of the more established lakes had a cement bar type boat ramp but sometimes it was covered in green slime closer and certainly within the water and a two wheel drive had all sorts of fun if one had to touch that slime with the rear tires.    A neighbor of mine had made a comment years back with his chev truck that was probably about the same year as yours but a half ton extended cab 4x4 and he a a fiberglass boat with an inboard so it wasn't a feather weight and he had gone out to one of the large popular lakes in the area and don't ask me how this happened but he was in two wheel drive as he figured he didn't require four wheel drive for that boat ramp and somehow upon pulling the boat out he twisted one of his drive axles. I suspect it must have spun and then grabbed on the cement ramp and shocked it to the degree of twisting it. He would have had the standard 8.5 or whatever it was axle housing as the 9.5 ring gear like my truck has also has larger drive axles as far as I know. Anyway he was feeling a vibration driving home and had it checked out and a shop found that the tire/hub was wobbling because of the axle had twisted so in went a new drive axle. After that bad experience he said he made sure to put it into four wheel drive to lower the stress on the rear axle. Of course that is where an HD truck can handle a lot more stress and no doubt these newer half tons with their larger ring gears probably have larger drive axles as well to match vs back in the day. 
    • asilverblazer
      2027 GMC Sierra: Official Discussion

      By asilverblazer · Posted

      Desirable - as in does someone WANT one, aspire to have one. Could reasonably buy any car they want and CHOOSE these instead.    I didn't watch the video, why did they win?
    • Atlas
      Towing In Loose Gravel

      By Atlas · Posted

      The use of absolutes like "always" to describe gear selection, and giving free advice at a boat ramp sounds like a recipe for disaster. It's a boat ramp, not a farm, for starters.   IMO gear selection should depend on the obstacle. If low range is working and this is a slower speed, controlled ordeal, I'd keep using that.

  • GM-Trucks.com Clubs

  • Popular Contributors

×
×
  • Create New...